Experimental Study of Liquid Slosh Dynamics in a Partially-Filled Tank

Abstract

This article reports on an experimental study conducted to investigate slosh forces and moments caused by fluid slosh within a partly-filled tank subjected to lateral and longitudinal excitations applied independently. The experiments were performed on a scale model cleanbore and a baffled tank with laterally placed single- and multiple-orifice baffles. The experiments were conducted for three different fill volumes and different types of excitations: continuous harmonic and single-cycle sinusoidal excitations of different amplitudes and discrete frequencies. The dynamic forces and moments caused by fluid slosh with the baffled and cleanbore tank configurations were measured for different fill volumes and excitations using three-axis dynamometers. It is shown that the resulting forces and moments comprise many spectral components that can be associated with the excitation, resonance, and vibration and beat frequencies. Modulation of excitation frequency with the resonant frequency was also evident for all fill conditions and tank configurations when the two were in close proximity. The results also showed that the peak amplifications of forces and moments occur in the vicinity of the resonant frequency. At higher frequencies, the peak magnitudes of the forces, however, reduced significantly to values lower than the inertial forces developed by an equivalent rigid mass. At a given excitation condition, the slosh force amplitude increased with a decrease in the fill volume. It was also observed that the presence of baffles has negligible effect on the lateral slosh force and the corresponding resonant frequency. However, it caused a significant increase in the longitudinal mode resonant frequency. The baffles greatly reduced the amplifications in longitudinal force and pitch moment under longitudinal acceleration excitations.